CHEMTRONICS
MSDS #1209L
Page 1 of 2
SECTION 1: CHEMICAL PRODUCT AND COMP ANY INFORMATION
Company Address:
8125 Cobb Center Drive
Kennesaw, GA 30152
Product Information: 800-TECH-401 Emergency: (Chemtrec) 800-424-9300
Customer Service: 800-645-5244 Revision Date: December 15, 2004
Produc t Identification
HEAD CLEANER
II (Liquid)
Product Code: ES820L, ES420L, ES820LC
SECTION 2: COMPOSIT ION/INFORMATION ON INGREDIENTS
Product Ingredient Information CAS# Wt. % Range
Isopropanol 67-63-0 95.0-99.0
Hexamethyldisiloxane 107-46-0 0.1-1.0
n-propyl acetate 109-60-4 1.0-5.0
SECTION 3: HAZARD IDENTIFICATION
Emergency Overview: Clear, colorless liquid with strong ethereal odor. This product is flammable. Liquid will irritate eyes and skin under repeated or prolonged
exposure. Breathing high concentrations of product vapor may produce drowsiness and a headache.
Potential Health Effects:
Eyes: Liquid, aerosols and vapors of this product are irritating and can cause pain, tearing, reddening and swelling accompanied by a stinging sensation.
Skin: Contact causes skin irritation.
Ingestion: Harmful if swallowed. Irritating to mouth, throat and stomach. May cause vomiting.
Inhalation: Harmful if inhaled. High concentrations of vapors in immediate area can displace oxygen and can cause dizziness, unconsciousness, and even death with
longer exposure. Keep people away from such vapors without self-contained breathing apparatus.
Pre-Existing Medical Conditions Aggravated by Exposure: Heart, lung, skin, eye.
SECTION 4: FIRST AID MEASURES
Eyes: Immediately flush with plenty of water. After initial flushing, remove any contact lenses and continue flushing for at least 15 minutes. H ave eyes examined
and tested by medical personnel if irritation develops or persists.
Skin: Wash skin with soap and water. Remove contaminated clothing. Get medical attention if irritation develops or persist. Wash clothing separately before
reuse.
Ingestion: Swallowing less than an ounce will not cause significant harm. For larger amounts, do not induce vomiting, but give one or two glasses of water to drink
and get immediate medical attention.
Inhalation: Remove to fresh air. If not breathi ng, gi ve artificial respiration. If breat hing is difficult , give oxygen. Get medic al attention.
SECTION 5: F I RE FIGHTING MEASURE S
Flash Point: 53°F (TCC ) LEL/UEL: Not established (% by volume in air)
Extinguishing Media: Use alcohol foam, carbon dioxide, or water spray when fighting fires involving this material.
Fire Fighting Instructions: As in any fire, wear self-contained breathing apparatus (pressure-demand, MSHA/NIOSH approved or equivalent) and full protective gear.
SECTION 6 : ACCIDENTAL RELEASE ME ASURES
Large Spills : Shut off leak if possible and safe to do so. Wear self-contained breathing apparatus and appropriate personal protective equipment. Absorb spill with
inert material (e.g. dry sand or earth), then place in a chemical waste container for proper disposal. Do not flush to sewer. Avoid runoff into storm sewers and ditches
which lead to wa terways.
Small S pills : Absorb spill with inert material (e.g. dry sand or earth), then place in a chemical waste container for proper disposal.
SECTION 7: HANDLING AND STORAGE
Avoid prolonged or repeated contact with eyes, skin, and clothing. Wash hands before eating. Use with adequate ventilation. Avoid breathing product vapor or mist.
Do not reuse this container. Store in a cool dry place away from heat, sparks and flame. Keep container closed when not in use. Do not store in direct sunlight.
KEEP OUT OF RE ACH OF CHILDREN.
SECTION 8: EXPOSURE CONTROLS/ P ERSONNEL PROT ECTION
Exposure Guidelines:
CHEMICAL NAME ACGIH TLV OSHA PEL ACGIH STEL
Isopropanol 200ppm 400ppm 400ppm
n-Propyl Acetate 200ppm 200ppm 250ppm
Hexamethyldisiloxane NA NA NA
Work/Hygienic Practices: Good general ventilation should be sufficient to control airborne levels. Local exhaust ventilation may be necessary to control any air
contaminants to within their TLVs during the use of this product. If vapor concentration exceeds TLV, use NIOSH approved organic vapor cartridge respirator.
Wear safety glas ses with side s hield s (or goggles) an d rubber or other chemically resistant gloves when handling this material.
NFPA and HMIS Codes: NFPA HMIS
Health 1 1
Flammability 3 3
Reactivity 1 1
Personal Protection - B
CHEMTRONICS
MSDS #1209L
Page 2 of 2
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIE S
Physical State: Clear, colorless liquid Solubility in Water: Negligible
Odor: Sweet s olvent Specific Grav ity: (Water =1) 0.79
pH: NA Evaporation Rate: <1
Vapor Pressure: 33 mm Hg @ 68°F (Butyl acetate=1)
Vapor Density: >1 @ 100°F Viscosity: 1 (Approx.)
(Air=1) (Water = 1)
Percent Volatile: 100% Melting Point: NA
Boiling Point: 180 F
SECTION 10: STABIL ITY AND REACTIVITY
Stability - This product is stable. Conditions to Avoid: Do not spray near open flames, red hot surfaces or other sources of ignition.
Incompatibility: Do not mix with powdered alkali and alkaline earth metals or strong oxidizing agents.
Products of Decomposition: Thermal decomposition may release carbon monoxide, carbon dioxide and incompletely burned hydrocarbons, as well as oxides of
silicone.
Hazardous Polymerization : Will not occur Conditions to Avoid: NA
SECTION 11: TOXICOLOGICAL INFORMAT ION
Inhalation: Ingestion:
Isopropanol LC50/rats 12,000ppm/8 hrs Isopropanol LD50/rats 5,800 mg/kg
n-Propyl Acetate TCLo/human 1,000 mg/m3 n-Propyl Acetate LD50/rats 9,370 mg/kg
Skin: Hexamethyldisiloxane LDLo rat 8 mL/kg
Isopropanol Rabbits MLD Eye:
n-Propyl Acetate Rabbits 500 mg open MLD n-Propyl Acetate rabbit 500 mg/24H MLD
Hexamethyldisiloxane Rabbits LD50 16 mL/kg Isopropanol rabbit 100 mg MLD-MOD
Cancer Information: No ingredients listed as human carcinogens by NTP or IARC
Reproductive effects: none Teratogenic effects: none Mutagenic effects: none
SECTION 12: ECOLOGICAL INF ORMATION
Environmental Impact Information
Avoid runoff into storm sewers and ditches, which lead to waterways. Water runoff can cause environmental damage.
REPORTING
US regulations requ ire reporting spills of this material t hat could reac h any surfa ce waters. The toll free number for the US Coast Guard National Response Center is:
1-800-424-8802
SECTION 13: DISPOSAL CONSIDERAT IONS
Dispose of in accordance with all federal, state and local regu lations. Water runoff can cause environmental damage.
SECTION 14: TRANSPORT ATION INFORMATION
Proper Hazard Sub. Pkg. Hazard Pkg. Max.
Shipping Name UN Number Class Risk Group Label Instr. Quantity
Air: Flammable liquids, n.o.s. UN 1993 3 NA II Flammable 305 5L
(Isopropanol) Liquid 307 60L
Ground: Consumer Commodity NA ORM-D NA NA ORM-D Pkg. 173.202
ORM-D Auth. 173.150
SECTION 15: REGULAT O RY INF O RMATION
SECTION 313 SUPPLIER NOTIFICATION This product contains no toxic chemicals subject to the reporting requirements of Section 313 of the Emergency Planning
and Community Right-To-Know Act of 1986 (40 CFR 372).
This information should be included on all MSDSs copied and distributed for this material.
TOXIC SU BSTANCES CONTROL ACT (TSCA).
All ingredients of this product are li sted on the TSCA Inventory.
WHMIS: Class B2; Class D2B
This product has been classified according to the hazard criteria of the CPR and the MSDS contains all of the information required by the CPR.
SECTION 16: OTHER INFORMATION
Normal ventilation for standard manufacturing practices is usually adequate. Local exhaust should be used when large amounts are released.
To the best of our knowledge, the information contained herein is accurate. However, all materials may present unknown hazards and should be used with caution. In
particular, improper use of our products and their inappropriate combination with other products and substances may produce harmful results which cannot be
anticipated. Final determination of the suitability of any material is the sole responsibility of the user. Although certain hazards are described herein, we cannot
gua r antee that these are the only haza r ds tha t ma y exi st.
